Samsco Wastewater Evaporator Swe-ii 400 Series

US $14000

Saint Louis, Missouri, United States
Jun 9th

Open on mobile:
QR code

THIS MACHINE IS THE 400 SERIES ALL SPECS ARE LISTED BELOW, VERY LOW HOURS! YOU CAN COME TO OUR LOCATION AND OPERATE IT FOR YOURSELF. SERIOUS BUYERS ONLY CALL PATRICK AT 314-614-1449 TO SET UP THE VIEWING. LOCATED IN ST. LOUIS MISSOURI,USA. The Samsco Water Evaporator II is Samsco’s flagship product, and has set the industry standard for water evaporator design and manufacturing. The SWE-II uses a system design that provides consistent operation, minimal cleanout, high efficiency and ease of maintenance. Specific features include: Redundant control/safety sensors utilizing technologies different from those of the primary sensors to avoid common-mode failures Integrated process control that maximizes reduction-in-volume (typically in the range of 90-99%) while providing accurate displays of operating conditions. Logical design incorporating a “wet” end for fluid management, a “dry” end for heat and electrical input and for controls, together with a “cold zone” for solids settling Three-stage mist elimination system Air-handling system keeping combustion products isolated from operator contact and safely contained away from personnel Optional condenser, modem, auto-drain, auto-overflow, etc. all under PLC control STANDARD FEATURES… WHAT THEY MEAN TO YOU… Stainless Steel Exterior Finish Greater ambient corrosion resistance Large, raised, NEMA 4 Control Enclosure Greater ambient moisture tolerance Screened, upward facing air inlet Minimizes waste splashing Additional headspace Easier skimming of foaming wastes Low bottom trough Additional settled sludge capacity Programmable logic controller with graphic display User-friendly system status with convenient, eye level display System process control Minimizes risk of waste over-concentration Fail-safe input Alarms on signal loss (broken wire, etc.) Emergency stop button (mushroom switch) Eye-catching safety (system shutoff) Triple-level security Ensures safe, approved operation Blower-off delay Lengthens blower-motor life & cuts operating cost Timed Auto-fill Improves level-control & reduces pump wear High-level alarm control Assures longer duty cycle Flue Temp Monitor Gives early warning of burner de-tuning Cycle time monitor Reduces maintenance time Integrated drain control Lowers installation cost & locks out auto-fill Samsco Water Evaporator II Models and Sizes SERIES 400 500 600 650 700 800/850 EVAPORATION RATE (gph) 8-10 15-18 33-39 48-52 63-68 126-160 24 HOUR EVAPORATION (gal.) 192 360 792 1,320 1,512 3,024 FOOTPRINT 65” x 23” 86” x 23” 85” x 43” 90” x 43” 98” x 43” 128” x 58” TANK CAPACITY (gal.) 118 174 333 312 296 517 HEAT SOURCES Natural Gas, Liquid Propane, Steam, Electricity CONSTRUCTION 316 Stainless, High Nickel Alloys, Chloride Resistant Alloys